1994 Volvo 960
1994 ACCESSORIES/SAFETY EQUIPMENT
Volvo Wiper/Washer System
960
All models are equipped with a 2-speed front wiper motor with an intermittent feature. Wagon models are equipped with a rear wiper/washer system.
WIPER ARM ADJUSTMENT
For wiper arm adjustment, refer to illustration. See Fig. 1.
Fig. 1: Adjusting Wiper Arms (960) Courtesy of Volvo Cars of North America
FRONT WIPER MOTOR
Removal & Installation
Disconnect negative battery cable. For front wiper motor removal and installation, refer to illustration. See Fig. 2.
To complete installation, reverse removal procedure.
Fig. 2: Removing Front Wiper Motor (960)
Removal & Installation
Front and rear wiper relays are located in relay box, in center console, behind ashtray.
FRONT & REAR WIPER SWITCH
Removal & Installation
Remove steering wheel. See STEERING WHEEL & HORN under REMOVAL & INSTALLATION in STEERING COLUMN SWITCHES article in the
ACCESSORIES/SAFETY EQUIPMENT section. Disconnect electrical connector. Remove wiper switch retaining screws. To install, reverse removal procedure.
FRONT & REAR WASHER MOTOR
Removal & Installation
Washer motor is located on washer fluid reservoir, front left corner of engine compartment. Disconnect electrical connector and lift motor off reservoir. See Fig. 3. Disconnect fluid lines. To install, reverse removal procedure.
Fig. 3: Removing Washer Motor (960)
Removal & Installation
For rear wiper motor removal and installation, refer to illustration. See Fig. 4.
Fig. 4: Removing Rear Wiper Motor Courtesy of Volvo Cars of North America
Fig. 5: Windshield/Headlt. Wiper/Washer System Wiring Diagram (960)
Fig. 6: Rear Wiper/Washer System Wiring Diagram (960)
Disclaimer: Volvotips has the exclusive courtesy of Volvo Car Corporation and Volvo Cars Heritage to publish the Volvo Greenbooks (service manual), parts catalogs and other Volvo-material and publications. Commercial use and publishing at other websites of these items is prohibited.